Page 17 of 18

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: May 2nd, 2018, 10:13 pm
by MISHI
Starting the process of getting my old girl back on the road but trying to amass the funds and location of parts...

Who sells gates timing belts (156x29)
GMB water pump (GWM47A)
4G91 tensioner/ rocker cover / plug seals etc for em over there?

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: May 3rd, 2018, 8:34 pm
by ray019
Good day tunersi know it's 2018 but I recently did a 4g93t gdi swap in my cs3 lancer, got the car u and running but it goes into limp mode once it reaches about 4-5k rpm, the check light comes on as well. When I check the diagnostic tool it says p1224 TAC, I changed the throttle body but same issue, anyone could shed some.light on this? I'm currently rewiring the car as the original harness I got was chopped up, my mechanic had run new wires for the chopped wires so to eliminate any wiring issue i got a new non chopped harness.

P.s even when in limp mode n I put it in tiptronic I get full power albeit a lazy throttle response

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: May 3rd, 2018, 9:56 pm
by MISHI
I think you answered your issue right there. When the car is rewired with the new harness then troubleshoot from there.

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: May 4th, 2018, 12:15 pm
by Kronik
If you had said the car had a lazy pull off and acting like it was stuck in 3rd gear,I would have had the answer to your problems. But the new harness should fix your issue

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: May 9th, 2018, 10:32 am
by ray019
Kronik wrote:If you had said the car had a lazy pull off and acting like it was stuck in 3rd gear,I would have had the answer to your problems. But the new harness should fix your issue



hey man the car is still rewiring but i would appreciate the knowledge.

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: May 9th, 2018, 11:51 am
by Kronik
ray019 wrote:
Kronik wrote:If you had said the car had a lazy pull off and acting like it was stuck in 3rd gear,I would have had the answer to your problems. But the new harness should fix your issue



hey man the car is still rewiring but i would appreciate the knowledge.
The problem I had was the main connector on the transmission, some wires had to swap and one other sensor was positioned differently on the transmission so I had to lengthen the wire for that one to plug in. I compared it to the cut harness I got and figured it out like that

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: May 13th, 2018, 9:18 pm
by Hone026
Hi I have a 1997 GALANT GDI 4G93 ,issues at start up misfires and pre-igniting does not start up. stop have another go does not start ,wait then it fires as normal no issues and it does this all the time hot or cold, the car runs normal with no issues till you go to fire it up. sometimes it fires up normal and no issues, replaced top gasket set as oil was leaking in to spark plugs, changed spark plugs still no change. cheers for any help

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: May 14th, 2018, 7:07 am
by Kronik
Hone026 wrote:Hi I have a 1997 GALANT GDI 4G93 ,issues at start up misfires and pre-igniting does not start up. stop have another go does not start ,wait then it fires as normal no issues and it does this all the time hot or cold, the car runs normal with no issues till you go to fire it up. sometimes it fires up normal and no issues, replaced top gasket set as oil was leaking in to spark plugs, changed spark plugs still no change. cheers for any help
Do you crank and stop and then crank again? Or do you crank non stop until it starts?

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: May 14th, 2018, 5:26 pm
by Hone026
Kronik wrote:
Hone026 wrote:Hi I have a 1997 GALANT GDI 4G93 ,issues at start up misfires and pre-igniting does not start up. stop have another go does not start ,wait then it fires as normal no issues and it does this all the time hot or cold, the car runs normal with no issues till you go to fire it up. sometimes it fires up normal and no issues, replaced top gasket set as oil was leaking in to spark plugs, changed spark plugs still no change. cheers for any help
Do you crank and stop and then crank again? Or do you crank non stop until it starts?

did the crank and stop crank and stop , finally it starts with no issues ... tried the continual crank , it misfires and splutters and of course turn off key wait a few sec's and it starts normal. ? very frustrating and we dont have a mitsi mechanic near by anymore

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: May 14th, 2018, 8:08 pm
by Kronik
Hone026 wrote:
Kronik wrote:
Hone026 wrote:Hi I have a 1997 GALANT GDI 4G93 ,issues at start up misfires and pre-igniting does not start up. stop have another go does not start ,wait then it fires as normal no issues and it does this all the time hot or cold, the car runs normal with no issues till you go to fire it up. sometimes it fires up normal and no issues, replaced top gasket set as oil was leaking in to spark plugs, changed spark plugs still no change. cheers for any help
Do you crank and stop and then crank again? Or do you crank non stop until it starts?

did the crank and stop crank and stop , finally it starts with no issues ... tried the continual crank , it misfires and splutters and of course turn off key wait a few sec's and it starts normal. ? very frustrating and we dont have a mitsi mechanic near by anymore
I have that problem, I need to crank for a few seconds before it starts, that's too build fuel pressure in the line, the regulator is bad, and GDI fuel pressures are very high

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: May 25th, 2018, 7:06 pm
by Hone026
Hey dude fixed all my issue got a second hand fuel pump with a good pressure regulator on it no it cranks first turn so try that cheers

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: May 28th, 2018, 2:45 pm
by ray019
ray019 wrote:Good day tunersi know it's 2018 but I recently did a 4g93t gdi swap in my cs3 lancer, got the car u and running but it goes into limp mode once it reaches about 4-5k rpm, the check light comes on as well. When I check the diagnostic tool it says p1224 TAC, I changed the throttle body but same issue, anyone could shed some.light on this? I'm currently rewiring the car as the original harness I got was chopped up, my mechanic had run new wires for the chopped wires so to eliminate any wiring issue i got a new non chopped harness.

P.s even when in limp mode n I put it in tiptronic I get full power albeit a lazy throttle response




UPdate, so the rewire fixed my limp mode issue, i'm getting full power now car drives great. i'm getting 5lbs boost.
But i notice the car lets out alot of black smoke and the burns a ridiculous amount of gas even while cruising.
any recommendations on what i could check?

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: May 28th, 2018, 5:10 pm
by Kronik
ray019 wrote:
ray019 wrote:Good day tunersi know it's 2018 but I recently did a 4g93t gdi swap in my cs3 lancer, got the car u and running but it goes into limp mode once it reaches about 4-5k rpm, the check light comes on as well. When I check the diagnostic tool it says p1224 TAC, I changed the throttle body but same issue, anyone could shed some.light on this? I'm currently rewiring the car as the original harness I got was chopped up, my mechanic had run new wires for the chopped wires so to eliminate any wiring issue i got a new non chopped harness.

P.s even when in limp mode n I put it in tiptronic I get full power albeit a lazy throttle response




UPdate, so the rewire fixed my limp mode issue, i'm getting full power now car drives great. i'm getting 5lbs boost.
But i notice the car lets out alot of black smoke and the burns a ridiculous amount of gas even while cruising.
any recommendations on what i could check?
Yeah I getting that same problem, once you floor it, is smoke and terrible fuel economy

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: July 16th, 2018, 2:26 pm
by turbo_beast369
Kronik wrote:
ray019 wrote:
ray019 wrote:Good day tunersi know it's 2018 but I recently did a 4g93t gdi swap in my cs3 lancer, got the car u and running but it goes into limp mode once it reaches about 4-5k rpm, the check light comes on as well. When I check the diagnostic tool it says p1224 TAC, I changed the throttle body but same issue, anyone could shed some.light on this? I'm currently rewiring the car as the original harness I got was chopped up, my mechanic had run new wires for the chopped wires so to eliminate any wiring issue i got a new non chopped harness.

P.s even when in limp mode n I put it in tiptronic I get full power albeit a lazy throttle response




UPdate, so the rewire fixed my limp mode issue, i'm getting full power now car drives great. i'm getting 5lbs boost.
But i notice the car lets out alot of black smoke and the burns a ridiculous amount of gas even while cruising.
any recommendations on what i could check?
Yeah I getting that same problem, once you floor it, is smoke and terrible fuel economy


Service your injectors and use premium gas

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: July 16th, 2018, 7:32 pm
by Kronik
turbo_beast369 wrote:
Kronik wrote:
ray019 wrote:
ray019 wrote:Good day tunersi know it's 2018 but I recently did a 4g93t gdi swap in my cs3 lancer, got the car u and running but it goes into limp mode once it reaches about 4-5k rpm, the check light comes on as well. When I check the diagnostic tool it says p1224 TAC, I changed the throttle body but same issue, anyone could shed some.light on this? I'm currently rewiring the car as the original harness I got was chopped up, my mechanic had run new wires for the chopped wires so to eliminate any wiring issue i got a new non chopped harness.

P.s even when in limp mode n I put it in tiptronic I get full power albeit a lazy throttle response




UPdate, so the rewire fixed my limp mode issue, i'm getting full power now car drives great. i'm getting 5lbs boost.
But i notice the car lets out alot of black smoke and the burns a ridiculous amount of gas even while cruising.
any recommendations on what i could check?
Yeah I getting that same problem, once you floor it, is smoke and terrible fuel economy


Service your injectors and use premium gas
How do you service the GDI injectors?

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: July 17th, 2018, 12:38 pm
by turbo_beast369
Kronik wrote:
turbo_beast369 wrote:
Kronik wrote:
ray019 wrote:
ray019 wrote:Good day tunersi know it's 2018 but I recently did a 4g93t gdi swap in my cs3 lancer, got the car u and running but it goes into limp mode once it reaches about 4-5k rpm, the check light comes on as well. When I check the diagnostic tool it says p1224 TAC, I changed the throttle body but same issue, anyone could shed some.light on this? I'm currently rewiring the car as the original harness I got was chopped up, my mechanic had run new wires for the chopped wires so to eliminate any wiring issue i got a new non chopped harness.

P.s even when in limp mode n I put it in tiptronic I get full power albeit a lazy throttle response




UPdate, so the rewire fixed my limp mode issue, i'm getting full power now car drives great. i'm getting 5lbs boost.
But i notice the car lets out alot of black smoke and the burns a ridiculous amount of gas even while cruising.
any recommendations on what i could check?
Yeah I getting that same problem, once you floor it, is smoke and terrible fuel economy


Service your injectors and use premium gas
How do you service the GDI injectors?


Remove them & carry them by a shop that tests/cleans fuel injectors.

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: August 2nd, 2018, 11:50 am
by Chriztoph3r
Hey guys.
My radiator blow out last night on my, 4g93t.....its a cs5w ralliart lancer wagon... yall have any for sale here... Thanks... Could WhatsApp me @ 3296909

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: October 31st, 2018, 12:12 pm
by dylan
Good day mitsu fam
In need of a 4g93T GSR turbo
Any help will be greatly appreciated

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: November 14th, 2018, 9:08 am
by matrixderoche
Did you get one as yet?

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: November 14th, 2018, 11:16 am
by nicholasfabulous
Would love to get my hands on one also these gdi so tiny lol

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: November 14th, 2018, 1:57 pm
by fras
not a direct swap, but subaru tdo4 is a good option!

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: December 7th, 2018, 11:04 am
by BoostJunkieXL
fras wrote:not a direct swap, but subaru tdo4 is a good option!


i have a little td04HL if you're interested...

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: December 9th, 2018, 1:20 pm
by Ted_v2
What application it came from?

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: December 9th, 2018, 3:33 pm
by racedriverpro
BoostJunkieXL wrote:
fras wrote:not a direct swap, but subaru tdo4 is a good option!


i have a little td04HL if you're interested...
Td04hla19t?

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: December 10th, 2018, 10:53 am
by BoostJunkieXL
i bought the turbo bout 3 years ago to do an upgrade when i had a gdi turbo in my lancer. i cant remember tbh but i can get a hold of it from the garage and let you know. i know its slightly bigger than the stock gdi turbo unit but smaller than tha airtrek unit.

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: February 10th, 2019, 12:32 pm
by kal3
Guys,
Can parts from a 4g93 non turbo such as pistons and rods work in a 93t?

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: February 10th, 2019, 4:45 pm
by mrich88
Why not use pistons and rods from a 93t?

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: February 10th, 2019, 8:14 pm
by kal3
Where can i get the 93t parts? Difficult to source?

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: February 19th, 2019, 3:33 pm
by MISHI
mrich88 wrote:Why not use pistons and rods from a 93t?



Pistons, yeah, but the rods are common across all 4g93s whether turbo or not. Either way it's best to use upgraded pistons and rods from stock and done.

Re: ALL 4G93T OWNERS - Post your most common problems !!!

Posted: March 10th, 2019, 10:33 am
by Parvin
mrich88 wrote:Why not use pistons and rods from a 93t?


Any idea where I could source some pistons?